| Bulletin Number | Vehicle Make | Vehicle Model | Model Year | Summary |
|---|---|---|---|---|
| 02142 | FORD | EXPLORER | 1996 | SOME VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION AND A 4.0L OHV ENGINE MAY EXHIBIT A NOISE / VIBRATION, NO DRIVE, UNUSUAL NOISE DURING CRANKING O |
| BC0318961101 | FORD | EXPLORER | 1996 | VIBRATION/SHUDDER AT 4000 - 5000 RPM WIDE OPEN THROTTLE. *TW<br /> |
| BC0313961101 | FORD | EXPLORER | 1996 | CHECK ENGINE LIGHT, CODE P030X, WITH NO DRIVEABILITY COMPLAINT. *TW<br /> |
| 5369 | FORD | EXPLORER | 1996 | SOME VEHICLES MAY EXHIBIT A FLUID LEAK CONCERN FROM THE FRONT AXLE VENT TUBE. *TT<br /> |
| 96223 | FORD | EXPLORER | 1996 | LONG CRANK - STICKING IDLE AIR CONTROL (IAC) VALVE - VEHICLES BUILT FROM 11/1/94 THROUGH 3/30/96 -STALL - AFTER STARTING WHEN ENGINE ALLOWED TO SOAK F |
| 962417 | FORD | EXPLORER | 1996 | NOISE - PINGING OR CREAKING FROM DRIVELINE WHEN VEHICLE IS PUT INTO GEAR. *TW<br /> |
| 962416 | FORD | EXPLORER | 1996 | VIBRATION - IN FLOOR PAN - AT WIDE OPEN THROTTLE (WOT) AND/OR STEADY HIGHWAY SPEEDS (70+ mph) - 5.0L VEHICLES WITH ALL WHEEL DRIVE (AWD) - EXPLORERS A |
| 96265 | FORD | EXPLORER | 1996 | MALFUNCTION INDICATOR LAMP (MIL) - DIAGNOSTIC TROUBLE CODES (DTCS) P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, AND/OR P0308 STORED IN MEMO |
| 962524 | FORD | EXPLORER | 1996 | ENGINE - 4.0L - NEW TORQUE-TO-YIELD CONNECTING ROD FASTENERS. *TW<br /> |
| 962510 | FORD | EXPLORER | 1996 | MALFUNCTION INDICATOR LAMP (MIL) - DIAGNOSTIC TROUBLE CODES (DTCS) P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307 AND/OR P0308 STORED IN MEMOR |
| 00264 | FORD | EXPLORER | 1996 | SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION ALONG WITH A P0420 DIAGNOSTIC TROUBLE CODE (DTC) STORED IN CONTINUOUS MEMORY |
| 980320 | FORD | EXPLORER | 1996 | GEAR DTC'S AND EXTENDED/DELAYED/ NO SHIFT. *AK<br /> |
| BC0833961009 | FORD | EXPLORER | 1996 | VEHICLE MAY EXHIBIT A 'POPPING' NOISE WHEN THE POWER WINDOWS IS LOWERED OR RAISED. *TT<br /> |
| BC0741961018 | FORD | EXPLORER | 1996 | FOR STALLING CONCERNS, REFLASH THE PCM W/ 96 CALIBRATION (R11 LEVEL). *TT<br /> |
| BC0740961018 | FORD | EXPLORER | 1996 | VEHICLES EXPERIENCE CHAFFING ON THE 14401 WIRE HARNESS CAUSING THE ACCESSORY FUSES TO BECOME OPEN (PRIMARILY THE CIGAR FUSE. *TT<br /> |
| 12283 | FORD | EXPLORER | 1996 | SOME VEHICLES MAY EXHIBIT A FLUID LEAK CONCERN FROM THE FRONT AXLE VENT TUBE. *TT<br /> |
| 980320 | FORD | EXPLORER | 1996 | SYMPTOMS WITH THE GEAR DTC'S AND EXTENDED / DELAYED / NO SHIFT / FLASHING FAULT INDICATOR LAMP. *YC<br /> |
| 96252 | FORD | EXPLORER | 1996 | LOCKS - REPLACE AND/OR REPAIR ANY LOCK COMPONENT - SERVICE TIP. *TW<br /> |
| 1014997020 | FORD | EXPLORER | 1996 | UPDATE TO TSB 96-21-9 ADDITIONAL CALIBRATION ADDED- ANY CALIBRATION REVISION LEVEL FOR A VEHICLE WITH A MANUAL TRANSMISSION THAT IS NOT CALLED OUT IN |
| 95161 | FORD | EXPLORER | 1996 | SHEET METAL-ROOF PANEL AND DRIP RAIL REPLACEMENT- SEAM SEALER APPLICATION PROCEDURE.*SD<br /> |
| 00234 | FORD | EXPLORER | 1996 | SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION ALONG WITH A P0420 DIAGNOSTIC TROUBLE CODE (DTC) STORED IN CONTINUOUS MEMORY |
| 96726 | FORD | EXPLORER | 1996 | WHEN REPLACING AN INTERNAL WIRING HARNESS ON 4R44E/4R55E TRANSMISSIONS BUILT BEFORE 11/30/95 WITH A NEW HARNESS, THE FLUID PAN MUST BE REPLACED ALSO. |
| 96715 | FORD | EXPLORER | 1996 | SUBJECT REGARDING A NEW SINGLE KEY LOCKSETS INSTALLED ON CERTAIN TRIAL VEHICLES. *TT<br /> |
| 96711 | FORD | EXPLORER | 1996 | SOME 4R70W TRANSMISSIONS WERE BUILT WITH A UNIQUE CASE AND REQUIRE A SPACER TO BE INSTALLED BETWEEN THE LOW / REVERSE SERVO COVER AND RETAINING RING. |
| 9676 | FORD | EXPLORER | 1996 | A CONDITION MAY EXIST WHERE THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND CODE 0446 MAY BE STORED IN MEMORY. *TT<br /> |
| 98610 | FORD | EXPLORER | 1996 | SOME VEHICLES MAY EXPERIENCE A STALL AND/OR STUMBLE DURING A COLD ENGINE DECEL. *YC<br /> |
| 95212 | FORD | EXPLORER | 1996 | THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATE |
| 951912 | FORD | EXPLORER | 1996 | ON TRANSMISSIONS BUILT BEFORE 6/20/95 (FIG 1) AN EXTENDED SHIFT AND A HIGHER ENGINE RPM THAN EXPECTED AND/OR NO SHIFT CONDITION, POSSIBLY ALONG WITH |
| 985A13 | FORD | EXPLORER | 1996 | THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE. *YC<br /> |
| 962619 | FORD | EXPLORER | 1996 | ENGINE - 4.0L - TORQUE-TO-YIELD (TTY) CRANKSHAFT DAMPER BOLT. *TW<br /> |
| BC9688961001 | FORD | EXPLORER | 1996 | INFORMATION FOR WHEN DIAGNOSING CONCERNS W/ FACTORY INSTALLED CELLULAR PHONES. *TT<br /> |
| 9749 | FORD | EXPLORER | 1996 | AXLE- FRONT AXLE LEAKS FLUID FROM VENT TUBE- VEHICLES BUILT THROUGH 8/96 EQUIPPED WITH 4X4 AND AWD. *JD<br /> |
Subscribe for our latest newslatters
Know if there is a safety problem with your vehicles, tires or car seat, and how to get it fixed.