| Bulletin Number | Vehicle Make | Vehicle Model | Model Year | Summary |
|---|---|---|---|---|
| SB-15-010 | HINO | NV8J | 2015 | Some vehicles that operate in extreme cold weather climates may exhibit ice accumulation on the EGR (Exhaust Gas Recirculation) butterfly plate with a |
| HINO 12-004 | HINO | NV8J | 2013 | SUBJECT VEHICLES:<br /> |
| HINO 12-002 TT | HINO | NV8J | 2013 | Some engines may erroneously record a P202E DTC in the DCU along with a P204F in the ECU. This fault condition is due to DCU software misdetection of |
| 167-B1911-01 | HINO | NV8J | 2020 | M0330 OUTSIDE MIRROR ADHESION LABOR TIME CHANGE<br /> |
| 167-P0804-12 | HINO | NV8J | 2008 | PTB 02-08 Arvin Meritor Reman Carrier Assy.<br /> |
| 167-R0801-12 | HINO | NV8J | 2009 | C0005 This Service Campaign includes instructions for the inspection and replacement of the shock absorbers used on the rear air suspension.<br /> |
| 167-R1306-12 | HINO | NV8J | 2013 | SB -13 - 001 Certain rear drive axles were improperly filled with non-synthetic differential fluid during assembly at the WV assembly plant instead of |
| 167-R1305-12 | HINO | NV8J | 2013 | RCB-001-13 When soot accumulates on the igniter surface, the burner ignition may perform improperly, which may cause the MIL (Malfunction Indicator La |
| 167-R1302-12 | HINO | NV8J | 2013 | RCB-002-13 ECU Enhancement. During vehicle operation, the Malfunction Indicator Lamp (MIL) may illuminate and/or the vehicle will experience reduced p |
| 167-R1301-12 | HINO | NV8J | 2010 | RCB-010-12 When soot accumulates in the DPF (Diesel Particulate Filter) due to aging degradation of the fuel injector, the engine control program coul |
| 167-R0906-12 | HINO | NV8J | 2009 | R0033 This bulletin includes the instructions for replacement of Davco fuel filter assembly components<br /> |
| 167-R0905-12 | HINO | NV8J | 2009 | R0030 This bulletin includes the instructions for the replacement of the fuel system hoses.<br /> |
| 167-R0904-12 | HINO | NV8J | 2009 | R0031 This bulletin includes the instructions for the replacement of the fuel system hoses on MDT vehicles equipped with dual fuel tanks.<br /> |
| 167-R0902-12 | HINO | NV8J | 2009 | R0034 This bulletin includes the instructions to complete the following. 1. Determine the condition of the fuel injectors by monitoring quantity valu |
| 167-R0901-12 | HINO | NV8J | 2009 | R0029 This bulletin includes instructions for the replacement of the fuel tank breather hose. If the vehicle is equipped with dual fuel tanks the brea |
| 167-B0503-12 | HINO | NV8J | 2017 | SB ? 05 - 010 CORRECTION TO WORKSHOP MANUALS FOR THE J08E ENGINE. a) Resistance between terminals of the air intake pre-heater relay should be 64.0 ? |
| 167-B0706-12 | HINO | NV8J | 2007 | SB - 07 - 003 This bulletin provides technical information on the redesigned axle breather that replaced the old (current) axle breather P/N A1199P139 |
| 167-B0703-12 | HINO | NV8J | 2008 | SB - 07 - 007 The document is to inform the dealers of the release of Hino Diagnostic eXplorer (HINO DX) Ver. 1.2.0<br /> |
| 167-B0701-12 | HINO | NV8J | 2008 | SB - 07 - 001 The document is to inform the dealers about the design change in the aligning marks on the flywheel.<br /> |
| 167-R0702-12 | HINO | NV8J | 2006 | R0019 This Emissions Recall involves inspection of the turbocharger part number, vehicle mileage and possible turbocharger replacement.<br /> |
| 167-B1625-12 | HINO | NV8J | 2018 | SB-16-021 CORRECTION OF WORKSHOP MANUAL FOR HINO600 SERIES Correction of Electrical Wiring Diagram<br /> |
| 167-B1623-12 | HINO | NV8J | 2017 | SB-16-019 An enhanced fuel cut valve is available to address a potential sticking condition that results in excess residual pressure in the dosing in |
| 167-B1619-12 | HINO | NV8J | 2016 | SB-16-006 Some vehicles built before January 2016 and equipped with a leaf spring rear suspension may experience a dislodged or missing spring pad. As |
| 167-B1618-12 | HINO | NV8J | 2017 | Addition of detailed explanation of the fuel pipe installation.<br /> |
| 167-T1429-12 | HINO | NV8J | 2015 | TT-14-033 When replacing an engine block with service part no., 11401E0380 there is potential that 2 rear oil passage plugs may be missing in the rear |
| 167-B1420-12 | HINO | NV8J | 2014 | SB-14-014 Subject vehicles may exhibit a concern where manual regeneration does not complete within one hour of depressing the manual regeneration but |
| 167-B1419-12 | HINO | NV8J | 2012 | SB-14-009 During inspection of one of the subject vehicles, the technician may notice loose or missing retainer nuts or bolts on the No.1 cross member |
| 167-B1418-12 | HINO | NV8J | 2015 | SB-14-012 A subject vehicle may exhibit an illuminated check engine lamp with DTC (Diagnostic Trouble Code) P0421 (Catalyst efficiency below threshold |
| 167-B1404-12 | HINO | NV8J | 2010 | SB-14-017 In the event that one of the subject vehicles is driven while the ABS warning lamp is illuminated, operation of the torque converter clutch |
| 167-B1403-12 | HINO | NV8J | 2014 | SB-14-016 In the event that one of the subject vehicles is driven while the ABS warning lamp is illuminated, operation of the torque converter clutch |
| 167-B1402-12 | HINO | NV8J | 2014 | SB-14-007 PROCEDURE FOR AUTO REGENERATION IS POSSIBLE BUT NOT MANUAL REGENERATION.<br /> |
| 167-B1401-12 | HINO | NV8J | 2015 | SB-14-029 CORRECTION OF WORKSHOP MANUAL FOR 2011 - 2015 MY. Troubleshooting information and inspection procedures for the DTC P2201 and P2214 were re |
| 167-B1408-12 | HINO | NV8J | 2015 | SB-14-028 CORRECTION OF WORKSHOP MANUAL FOR 2011- 2015 MY. Troubleshooting information and Inspection procedure of the DTC/P207F were revised.<br /> |
| 167-B1407-12 | HINO | NV8J | 2014 | SB-14-025 Subject vehicles may exhibit electrical symptoms which can include, but are not limited to erratic operation of the exterior lamps, warning |
| 167-B1406-12 | HINO | NV8J | 2007 | SB-14-019 In the event that one of the subject vehicles is driven while the ABS warning lamp is illuminated, operation of the torque converter clutch |
| 167-B1408-12 | HINO | NV8J | 2015 | SB-14-028 CORRECTION OF WORKSHOP MANUAL FOR 2011- 2015 MY. Troubleshooting information and Inspection procedure of the DTC/P207F were revised.<br /> |
| 167-B1407-12 | HINO | NV8J | 2014 | SB-14-025 Subject vehicles may exhibit electrical symptoms which can include, but are not limited to erratic operation of the exterior lamps, warning |
| 167-B1406-12 | HINO | NV8J | 2007 | SB-14-019 In the event that one of the subject vehicles is driven while the ABS warning lamp is illuminated, operation of the torque converter clutch |
| 167-R1407-12 | HINO | NV8J | 2015 | T0280 During installation of the air pressure sensors on the air tanks, it is possible that they could have been damaged causing incorrect air pressur |
| 167-R1405-12 | HINO | NV8J | 2010 | RCB-010-12 When soot accumulates in the DPF (Diesel Particulate Filter) due to aging degradation of the fuel injector, the engine control program coul |
| 167-R1404-12 | HINO | NV8J | 2014 | RCB-005-14 When a subject vehicle is operated at low temperatures, the DEF (Diesel Exhaust Fluid) in the DEF hose may freeze, which may cause the on-b |
| 167-R1401-12 | HINO | NV8J | 2014 | RCB-004-13 When a subject vehicle is operated at low temperatures, the DEF (Diesel Exhaust Fluid) in the DEF hose may freeze, which may cause the on-b |
| 167-T1301-12 | HINO | NV8J | 2013 | 13-001 SCR COOLANT HOSE CLAMP.<br /> |
| 167-T1204-12 | HINO | NV8J | 2012 | 12 - 002 Diagnosis Procedure for P2457. Some engines may erroneously record a P2457 DTC in the ECU. This fault condition is due to ECU software misdet |
| 167-T1203-12 | HINO | NV8J | 2013 | 12 - 002 Diagnosis Procedure for P202E (DCU) Associated with P204F (ECU) Some engines may erroneously record a P202E DTC in the DCU along with a P204F |
| 167-B1414-12 | HINO | NV8J | 2015 | SB-14-020 When replacing a broken hood grille, an enhanced replacement hood grille is available. This procedure should be used when installing this en |
| 167-T1201-12 | HINO | NV8J | 2013 | 12-004 "Exhaust Gas Temp" (DPR Outlet) Reading Error<br /> |
| 167-B1416-12 | HINO | NV8J | 2014 | SB-14-013 "DPR damage", "Burner misfire due to excessive soot on the burner igniter surface", and "DPR push out" may occur due to the increase in the |
| 167-B1415-12 | HINO | NV8J | 2009 | SB-14-003 The following is to inform you of the revision of the inspection procedure for the DTC?s P0340 and P0341. You are kindly requested to attach |
| 167-T1416-12 | HINO | NV8J | 2015 | |
| 167-B1616-12 | HINO | NV8J | 2016 | SB-16-004 1. In the event that a subject vehicle exhibits an illuminated check engine lamp and DTC?s P2201, P2214, P206B, P207F, or P20EE are stored |
| 167-B1602-12 | HINO | NV8J | 2017 | SB-16-015 Enhanced DCU (Dosing Control Unit) software has been released.Illumination of the check engine light. The DCU may falsely detect an issue an |
| 167-B1601-12 | HINO | NV8J | 2015 | SB-16-007 If DTC(Diagnostic Trouble Code) P0611:Fuel Injector Driver Charge Circuit - Circuit Low has set in the engine ECU(Electronic Control Unit) a |
| 167-B1513-12 | HINO | NV8J | 2014 | SB-15-014 CORRECTION OF WORKSHOP MANUAL FOR 2011MY-2014MY (ADDITION AND CORRECTION OF BURNER SYSTEM)<br /> |
| 167-T0702-12 | HINO | NV8J | 2007 | 07 ? 002 OIL IN AIR COMPRESSOR INLET LINE. Oil in Air Compressor inlet line. Oil can be pulled the entire length of the air compressor line whereas s |
| 167-B1311-12 | HINO | NV8J | 2013 | 13-014 An audible seat squeak may occur from the driver seat and/or single occupant passenger seat while driving over rough roads. This audible squeak |
| 167-B1302-12 | HINO | NV8J | 2013 | SB -13 - 001 Incorrect Rear Axle Differential Fluid. Certain rear drive axles were improperly filled with non-synthetic differential fluid during asse |
| 167-B1103-12 | HINO | NV8J | 2012 | SB-11-005 INFORMATION AND PROCEDURE FOR CHECKING AND CLEANING OF THE BREATHER HOSE ON THE DEF TANK. The breather hose can clog up with crystallized DE |
| 167-B0903-12 | HINO | NV8J | 2010 | SB ? 09 - 001 This bulletin provides diagnostic information for monitoring the engine running data to determine if the Suction Control Valve is defect |
| 167-B0901-12 | HINO | NV8J | 2010 | SB - 09 - 003 This bulletin provides a procedure to modify the Intake Throttle Valve.<br /> |
| 167-R1603-12 | HINO | NV8J | 2016 | SCB-001-16 A subject vehicle may exhibit an illuminated check engine lamp with DTC (Diagnostic Trouble Code) P14BF ?EGR (Exhaust Gas Recirculation) V |
| 167-R0902-12 | HINO | NV8J | 2010 | RCB-003-11 This bulletin involves the inspection of the Variable Nozzle Turbine (VNT) turbocharger linkrod along with the potential replacement of the |
| 167-R0401-12 | HINO | NV8J | 2005 | C0002 Hino Motors Sales U.S.A., Inc. has determined that the transmission oil cooler on vehicles equipped with an Allison MD 3060 Automatic Transmissi |
| 167-R0601-12 | HINO | NV8J | 2006 | C0004 This Service Campaign involves the replacement of the snap-ring and the installation of the grommet located on the transmission oil-cooler inlet |
| 167-A1401-12 | HINO | NV8J | 2013 | A-15-008 A subject vehicle may experience DPR (Diesel Particulate Reduction) system related issues in extreme cold weather conditions. If a good fuel |
| 167-B1420-12 | HINO | NV8J | 2013 | SB-14-014 Subject vehicles may exhibit a concern where manual regeneration does not complete within one hour of depressing the manual regeneration but |
| 167-B1419-12 | HINO | NV8J | 2012 | SB-14-009 During inspection of one of the subject vehicles, the technician may notice loose or missing retainer nuts or bolts on the No.1 cross member |
| 167-B1416-12 | HINO | NV8J | 2013 | SB-14-013 "DPR damage", "Burner misfire due to excessive soot on the burner igniter surface", and "DPR push out" may occur due to the increase in the |
| 167-B1414-12 | HINO | NV8J | 2013 | SB-14-020 When replacing a broken hood grille, an enhanced replacement hood grille is available. This procedure should be used when installing this en |
| 167-B1203-12 | HINO | NV8J | 2013 | SB-12-002 Flame Temperature Sensor Replacement Guidelines. 2. CONDITION: Many Flame Temperature Sensors are being replaced for burner failure (as sho |
| 167-B0806-12 | HINO | NV8J | 2009 | 08 - 003 This document is to inform dealers and workshops of the design change to the supply pump and SCV for J08E-TV, TW engine series.<br /> |
| 167-B0805-12 | HINO | NV8J | 2009 | 08 - 003 This document is to inform dealers and work shops to the update of inlet and outlet fuel pipes on the Davco fuel filter assembly.<br /> |
| 167-B0802-12 | HINO | NV8J | 2008 | SB - 08 - 001 This document is to inform dealers and workshops on the installation procedures for a crankcase breather (ventilator) anti freezing kit. |
| 167-B0801-12 | HINO | NV8J | 2009 | SB ? 07 - 006 This bulletin provides diagnostic information for monitoring the engine running data to determine if the Suction Control Valve is defect |
| 167-B1420-12 | HINO | NV8J | 2014 | SB-14-014 Subject vehicles may exhibit a concern where manual regeneration does not complete within one hour of depressing the manual regeneration but |
| 167-B1419-12 | HINO | NV8J | 2012 | SB-14-009 During inspection of one of the subject vehicles, the technician may notice loose or missing retainer nuts or bolts on the No.1 cross member |
| 167-B1418-12 | HINO | NV8J | 2015 | SB-14-012 A subject vehicle may exhibit an illuminated check engine lamp with DTC (Diagnostic Trouble Code) P0421 (Catalyst efficiency below threshold |
| 167-T1406-12 | HINO | NV8J | 2014 | 14-002 ELECTRICAL ISSUES OR FALSE STARTER ENGAGEMENT DUE TO COOLANT INTRUSION INTO JUNCTION BOX<br /> |
| 167-B1626-12 | HINO | NV8J | 2014 | SB-16-022 A subject vehicle may experience an external fuel leak from the burner atomization module assembly, specifically the fuel pressure regulato |
| 167-T1603-12 | HINO | NV8J | 2014 | TT-16-001<br /> |
| 167-B1004-12 | HINO | NV8J | 2010 | 10 - 001 Starter Assembly Mounting Nuts Torque Correction. The following is to inform you of the correction made to the Workshop Manuals<br /> |
| 167-B1003-12 | HINO | NV8J | 2010 | SB-10-004 This document is to inform dealers and workshops of the procedures on applying an anti-seize lubricant to the VNT Turbocharger link rod for |
| 167-B1001-12 | HINO | NV8J | 2011 | SB ? 10 - 003 This bulletin provides technical information for proper Fuel Filter usage as well as an example of damage caused by foreign material all |
| 167R040112 | HINO | NV8J | 2005 | C0002 Hino Motors Sales U.S.A., Inc. has determined that the transmission oil cooler on vehicles equipped with an Allison MD 3060 Automatic Transmissi |
| SB-R-0025 | HINO | NV8J | 2008 | HINO TRUCKS: UNDER CERTAIN DRIVING CONDITIONS, THE ENGINE CONTROL PROGRAM DOES NOT PROVIDE SATISFACTORY DRIVABILITY CHARACTERISTICS. |
| RCB-001-13 | HINO | NV8J | 2013 | HINO: SOOT ACCUMULATES ON THE IGNITER. BURNER IGNITION COULD PERFORM IMPROPERLY. REPLACEMENT OF THE DIESEL PARTICULATE REGENERATION (DPR) IGNITER PLUG |
| RCB-009-12 | HINO | NV8J | 2013 | HINO: SOFTWARE UPDATE FOR BURNER CONTROL UNIT (BCU). IGNITION OF THE BURNER SYSTEM MAY PERFORM IMPROPERLY AND CAUSE A MIL LIGHT TO ILLUMINATE IN THE I |
| RCB-002-13 | HINO | NV8J | 2013 | HINO TRUCKS: MALFUNCTION INDICATOR LAMP (MIL) MAY BE ILLUMINATING. VEHICLE MAY ALSO EXPERIENCE REDUCED POWER. PERFORMING A SOFTWARE ENHANCEMENT SHOULD |
| RCB-008-12 | HINO | NV8J | 2012 | HINO TRUCKS: MALFUNCTION INDICATOR LAMP (MIL) POSSIBLY ILLUMINATING DURING COLD TEMPERATURES. SOFTWARE UPDATE FOR THE DOSING CONTROL UNIT (DCU) COULD |
Subscribe for our latest newslatters
Know if there is a safety problem with your vehicles, tires or car seat, and how to get it fixed.