Manufacturer Communications
Vehicles / International / Lonestar
| Bulletin Number | Vehicle Make | Vehicle Model | Model Year | Summary |
|---|---|---|---|---|
| 20905 | INTERNATIONAL | LONESTAR | 2020 | Recalibrate Transmission Control Unit (TCU) software to improve Linear Clutch Actuator (LCA) performance and mitigate possible transmission service la |
| 21102 | INTERNATIONAL | LONESTAR | 2021 | The air filter elements may debond resulting in dirt entering the engine intake.<br /> |
| 21101 | INTERNATIONAL | LONESTAR | 2021 | The deaeration tank may leak coolant.<br /> |
| IK1200431 | INTERNATIONAL | LONESTAR | 2006 | Cummins Ambient Air Temperature (AAT) Sensor Located Rear of Vehicle; Only models with Cummins ISX or ISM engines<br /> |
| IK1100025 | INTERNATIONAL | LONESTAR | 2013 | Clutch Service Information; only models with Hydraulic Clutch Systems<br /> |
| IK0800369 | INTERNATIONAL | LONESTAR | 2006 | Cummins Active Fault Code 249 / 256 Ambient Air Temperature Sensor; only models with Cummins ISX or ISM engines<br /> |
| IK1600251 | INTERNATIONAL | LONESTAR | 2020 | Water Leaks Past Plastic Vapor Barrier Sheet in the Inner Cavity of the Cab Entry Door<br /> |
| IK1600207 | INTERNATIONAL | LONESTAR | 2020 | Wind noise at upper side of cab door due to door out of alignment<br /> |
| IK0800584 | INTERNATIONAL | LONESTAR | 2020 | Auxiliary Engine Speed Control Cannot Hold Engine Speed When Using Steering Wheel Switches<br /> |
| IK1300174 | INTERNATIONAL | LONESTAR | 2020 | Power Take Off (PTO) Programming on LT, RH and LoneStar Models with the Eaton Endurant¿ Transmission; only models with feature code 13GZD, 13GY |
| IK1600245 | INTERNATIONAL | LONESTAR | 2020 | Cab Door Latch Stuck, Door will not open<br /> |
| IK1900257 | INTERNATIONAL | LONESTAR | 2020 | Day Cab Roof Air Deflector Vibrates against Cab Roof; only models with P/N 4067947C92 Roof Air Deflector<br /> |
| IK0800585 | INTERNATIONAL | LONESTAR | 2020 | Winter Fuel Or Additive Use Required Pop-Up Message<br /> |
| IK0500038 | INTERNATIONAL | LONESTAR | 2020 | Steering Shake, Shimmy, Shudder, Steering Vibration; Only ProStar / LoneStar and LT / RH with 14k front weight rated axles and below<br /> |
| IK0800444 | INTERNATIONAL | LONESTAR | 2020 | Driver Information Display (VIS/DID) screen fails to boot up.<br /> |
| IK0800284 | INTERNATIONAL | LONESTAR | 2020 | Ambient Air Temperature (AAT) Sensor Faults/Location/Diagnostics<br /> |
| IK0400159 | INTERNATIONAL | LONESTAR | 2020 | Bendix EC80 Blank Module Replacement Program; This document will guide the user through selecting the correct ABS module when it has been determined a |
| IK1700017 | INTERNATIONAL | LONESTAR | 2019 | vibration at highway speeds; only vehicles with low miles<br /> |
| 19903 | INTERNATIONAL | LONESTAR | 2020 | The battery discharge protection system may have an incorrect relay resulting in no battery discharge protection and no notification displayed on the |
| 19104 | INTERNATIONAL | LONESTAR | 2020 | A deformation in the center post of the switch pack housing may cause one or more of the switches to become loose and / or pop out when depressed.<br |
| IK1600027 | INTERNATIONAL | LONESTAR | 2007 | Cab Ride Height Specifications and Adjustment Procedures<br /> |
| 19108 | INTERNATIONAL | LONESTAR | 2017 | Certain LoneStar® models may have been built without transmission oil cooler lines.<br /> |
| IK0800579 | INTERNATIONAL | LONESTAR | 2019 | Xantrex 1200W Power Inverter Information; only models with feature code 0008XLD<br /> |
| IK0800510 | INTERNATIONAL | LONESTAR | 2019 | Cooper Bussmann Inverter Information/Diagnostics; only models with feature code 0008XDM or 0008XDN and built after 05/12/2014<br /> |
| IK0800460 | INTERNATIONAL | LONESTAR | 2019 | Build to VIN Wiring Harnesses<br /> |
| IK0800059 | INTERNATIONAL | LONESTAR | 2019 | Brake Lights Staying On<br /> |
| IK0800017 | INTERNATIONAL | LONESTAR | 2019 | Programing New Key Fobs<br /> |
| IK0800579 | INTERNATIONAL | LONESTAR | 2019 | Xantrex 1200W Power Inverter Information; only models with feature code 0008XLD<br /> |
| IK1700017 | INTERNATIONAL | LONESTAR | 2018 | vibration at highway speeds; only with low miles<br /> |
| IK0800579 | INTERNATIONAL | LONESTAR | 2019 | Xantrex 1200W Power Inverter Information; only models with feature code 0008XLD<br /> |
| IK0800510 | INTERNATIONAL | LONESTAR | 2019 | Cooper Bussmann Inverter Information/Diagnostics; only models with feature code 0008XDM or 0008XDN and built after 05/12/2014<br /> |
| IK1100031 | INTERNATIONAL | LONESTAR | 2014 | Hard to Crank Condition on Vehicles with Hydraulic Clutch Linkage and Solo Clutch<br /> |
| IK1500074 | INTERNATIONAL | LONESTAR | 2014 | Fuel Filters, Winter Additives, and Blending Fuels; only models equipped with Cummins engine<br /> |
| IK1200940 | INTERNATIONAL | LONESTAR | 2014 | SCR Fluid Filter Replacement; only with Cummins ISX or Navistar N13 Diesel Exhaust Fluid System<br /> |
| IK1700017 | INTERNATIONAL | LONESTAR | 2019 | vibration at highway speeds<br /> |
| IK1700017 | INTERNATIONAL | LONESTAR | 2018 | Vibration at highway speeds; Only units with low mileage<br /> |
| IK0900128 | INTERNATIONAL | LONESTAR | 2018 | Identifying customer HVAC performance concerns / Evaporator Freeze up<br /> |
| IK0700072 | INTERNATIONAL | LONESTAR | 2014 | ISX Setting 3556-18 (FC3167), 5298-18 (FC1691), or 3482-2 (FC1925) Caused by Missing AFI Poppet<br /> |
| IK0800201 | INTERNATIONAL | LONESTAR | 2007 | Disable Cummins Icon; Only models equipped with Cummins engine and with Icon installed.<br /> |
| IK1600171 | INTERNATIONAL | LONESTAR | 2007 | Espar Heater; only models with Feature Code 16UZL<br /> |
| IK0800404 | INTERNATIONAL | LONESTAR | 2007 | Circuit diagram for ProStar/LoneStar Fifth wheel; link to missing diagram.<br /> |
| IK1900233 | INTERNATIONAL | LONESTAR | 2014 | No Idle HVAC Solution Parts Identification; only with feature 16UZL No Idle HVAC<br /> |
| IK1900232 | INTERNATIONAL | LONESTAR | 2014 | Sleeper Fan and Sleeper TEMP Switch Inoperative<br /> |
| IK1900231 | INTERNATIONAL | LONESTAR | 2014 | Rear A/C Control Panel Inoperative<br /> |
| IK1900230 | INTERNATIONAL | LONESTAR | 2014 | Rear A/C Blows Warm Air<br /> |
| IK1900228 | INTERNATIONAL | LONESTAR | 2014 | Air Conditioning Diagnostics<br /> |
| IK1900226 | INTERNATIONAL | LONESTAR | 2014 | Air Conditioning Control Head Diagnostics<br /> |
| IK1900207 | INTERNATIONAL | LONESTAR | 2014 | HVAC Diagnostic Information<br /> |
| AFC 14906 | INTERNATIONAL | LONESTAR | 2015 | Clutch Switch Inspection and Replacement.<br /> |
| IK1200940 | INTERNATIONAL | LONESTAR | 2014 | SCR Fluid Filter Replacement; only with Cummins ISX or Navistar N13 Diesel Exhaust Fluid System<br /> |
| IK0300004 | INTERNATIONAL | LONESTAR | 2007 | |
| IK0900075 | INTERNATIONAL | LONESTAR | 2007 | Horton Stratis Fan Hub Diagnostics<br /> |
| IK1900198 | INTERNATIONAL | LONESTAR | 2017 | MaxxPower No Idle Battery-Powered A/C System Diagnostic Guide; models equipped with feature 16UZL<br /> |
| IK1201383 | INTERNATIONAL | LONESTAR | 2018 | LoneStar Air Filter Service Procedure<br /> |
| IK1600237 | INTERNATIONAL | LONESTAR | 2018 | Bunk Curtain Falling Off Track Sky-Rise<br /> |
| IK0800246 | INTERNATIONAL | LONESTAR | 2007 | Manual Mode Button on the Eaton Shift Console is flashing with No Active Codes in the TCM. With Active Code 3655, 3654 or 3656 in the Body Controller; |
| IK0700019 | INTERNATIONAL | LONESTAR | 2013 | Water Leaking from Exhaust Pipe Joint; only vehicles with Horizontal Aftertreatment and Vertical Tailpipe<br /> |
| REC13514 | INTERNATIONAL | LONESTAR | 2014 | On vehicles with the electronic jaw release system, the airlines at the isolation/vent valve may not be oriented correctly to the valve ports at the t |
| IK0900118 | INTERNATIONAL | LONESTAR | 2015 | MaxxPower Condenser Fan Diagnostics with the MaxxPower No-idle System (16UZL)<br /> |
| IK0800427 | INTERNATIONAL | LONESTAR | 2007 | Active Faults During Load Shed<br /> |
| IK1100031 | INTERNATIONAL | LONESTAR | 2014 | Hard to Crank Condition on Vehicles with Hydraulic Clutch Linkage and Solo Clutch<br /> |
| IK1100020 | INTERNATIONAL | LONESTAR | 2014 | |
| IK1100005 | INTERNATIONAL | LONESTAR | 2007 | Eaton Clutch Information<br /> |
| IK1100004 | INTERNATIONAL | LONESTAR | 2007 | Clutch Linkage Rattle<br /> |
| IK1600104 | INTERNATIONAL | LONESTAR | 2014 | Filler Panels Interfere With Door Operation<br /> |
| IK1900207 | INTERNATIONAL | LONESTAR | 2014 | 2010 and later HVAC Diagnostic Information<br /> |
| IK1900198 | INTERNATIONAL | LONESTAR | 2014 | MaxxPower No Idle Battery-Powered A/C System Diagnostic Guide; models equipped with feature 16UZL<br /> |
| IK0800485 | INTERNATIONAL | LONESTAR | 2014 | Cluster Issues<br /> |
| IK1900240 | INTERNATIONAL | LONESTAR | 2015 | Pressure Transducer (PT) Switch Install<br /> |
| IK1900237 | INTERNATIONAL | LONESTAR | 2015 | Symptom 3: NoIdle HVAC Inoperative<br /> |
| IK1600116 | INTERNATIONAL | LONESTAR | 2015 | Mirror / Map Light / Visor LED Lighting Up when CB MIC is keyed<br /> |
| IK1900239 | INTERNATIONAL | LONESTAR | 2015 | MaxxPower No Idle Battery-Powered A/C System Diagnostic Guide; models equipped with feature 16UZL<br /> |
| IK1900228 | INTERNATIONAL | LONESTAR | 2015 | Vehicle Air Conditioning Diagnostics (Start Here)<br /> |
| IK1900207 | INTERNATIONAL | LONESTAR | 2015 | HVAC Diagnostic Information<br /> |
| IK0400146 | INTERNATIONAL | LONESTAR | 2007 | N13, MaxxForce 11, 13 engine Two Cylinder Air Compressor Testing<br /> |
| IK0400057 | INTERNATIONAL | LONESTAR | 2007 | Newer Brake Light Operation<br /> |
| IK1900239 | INTERNATIONAL | LONESTAR | 2015 | Symptom 5: NoIdle HVAC Blows Warm Air<br /> |
| IK1900237 | INTERNATIONAL | LONESTAR | 2015 | Symptom 3: NoIdle HVAC Inoperative<br /> |
| IK1900234 | INTERNATIONAL | LONESTAR | 2015 | Symptom 1: No Idle HVAC Cools but Operates Incorrectly<br /> |
| IK1900198 | INTERNATIONAL | LONESTAR | 2015 | ESPAR D5 Hydronic Diagnostic Guide<br /> |
| IK1600219 | INTERNATIONAL | LONESTAR | 2015 | ESPAR Preventative Maintenance / Inpection<br /> |
| IK0300008 | INTERNATIONAL | LONESTAR | 2007 | Vibration Troubleshooting<br /> |
| REC15V-607 | INTERNATIONAL | LONESTAR | 2014 | The fifth wheel and its locking mechanism may be susceptible to cumulative damage resulting in the fifth wheel lock to function improperly or a failur |
| IK1900239 | INTERNATIONAL | LONESTAR | 2015 | Symptom 5: NoIdle HVAC Blows Warm Air<br /> |
| IK1900235 | INTERNATIONAL | LONESTAR | 2015 | No-Idle HVAC Operational Check - STARTING POINT<br /> |
| IK1900239 | INTERNATIONAL | LONESTAR | 2015 | Symptom 5: No-Idle HVAC Blows Warm Air<br /> |
| IK1900238 | INTERNATIONAL | LONESTAR | 2015 | Symptom 4: No-Idle HVAC Digital Display Inoperative<br /> |
| IK1900237 | INTERNATIONAL | LONESTAR | 2015 | Symptom 3: No-Idle HVAC Inoperative<br /> |
| IK1900236 | INTERNATIONAL | LONESTAR | 2015 | Symptom 2: No-Idle HVAC Fault Codes<br /> |
| IK1900235 | INTERNATIONAL | LONESTAR | 2015 | No-Idle HVAC Operational Check - STARTING POINT<br /> |
| IK1900234 | INTERNATIONAL | LONESTAR | 2015 | Symptom 1: No Idle HVAC Cools but Operates Incorrectly<br /> |
| REC17502 | INTERNATIONAL | LONESTAR | 2018 | The air dryer mounting bracket may fracture, which could cause the air dryer to separate from the vehicle frame with possible airline separation from |
| 15517 | INTERNATIONAL | LONESTAR | 2014 | Accelerator pedal sensor (APS) recalibration<br /> |
| IK1900207 | INTERNATIONAL | LONESTAR | 2015 | HVAC Diagnostic Information<br /> |
| IK1900198 | INTERNATIONAL | LONESTAR | 2015 | MaxxPower No Idle Battery-Powered A/C System Diagnostic Guide; equipped with Feature 16UZL<br /> |
| IK0800427 | INTERNATIONAL | LONESTAR | 2007 | Active Faults During Load Shed<br /> |
| IK1900240 | INTERNATIONAL | LONESTAR | 2015 | Pressure Transducer (PT) Switch Install<br /> |
| IK1900228 | INTERNATIONAL | LONESTAR | 2015 | Vehicle Air Conditioning Diagnostics (Start Here)<br /> |
| IK1900225 | INTERNATIONAL | LONESTAR | 2015 | Air Conditioning Mechanical Pressures Diagnostics<br /> |
| IK1900223 | INTERNATIONAL | LONESTAR | 2015 | Air Conditioning Electrical Diagnostics<br /> |
| IK1900198 | INTERNATIONAL | LONESTAR | 2015 | MaxxPower No Idle Battery-Powered A/C System Diagnostic Guide; models equipped with feature 16UZL<br /> |
| IK0900110 | INTERNATIONAL | LONESTAR | 2015 | Coolant odor in cab with rear HVAC; equipped with Feature 0595BJN or 0595BWZ<br /> |
| IK0800510 | INTERNATIONAL | LONESTAR | 2015 | Cooper Bussmann Inverter Information/Diagnostics; equipped with feature 08XDM or 08XDN<br /> |
| IK0400088 | INTERNATIONAL | LONESTAR | 2015 | Brake Single Hot Wheel End Service Procedure<br /> |
| IK1900172 | INTERNATIONAL | LONESTAR | 2014 | ESPAR HEATER DIAGNOSTIC GUIDE<br /> |
| IK1600116 | INTERNATIONAL | LONESTAR | 2017 | Mirror / Map Light / Visor LED Lighting Up when CB MIC is Keyed<br /> |
| IK1900245 | INTERNATIONAL | LONESTAR | 2015 | ESPAR D5 Hydronic Diagnostic Guide<br /> |
| IK0400057 | INTERNATIONAL | LONESTAR | 2007 | NEW BRAKE LIGHT OPERATION; PROSTAR AND LONESTAR WITH AIR BRAKES<br /> |
| AFC-10922 | INTERNATIONAL | LONESTAR | 2010 | NAVISTAR SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SOME AXLE THROUGH SHAFTS MAY HAVE NOT BEEN PROPERLY HEAT TREATED AND MAY RESUL |
| 14906 | INTERNATIONAL | LONESTAR | 2014 | LONE STAR, PROSTAR: CLUTCH SWITCH NEED REPLACING AND INSPECTED, IN CERTAIN MODELS BUILT BETWEEN MARCH 01, 2013-04 FEB 2014 *LJ<br /> |
| IK-0800377 | INTERNATIONAL | LONESTAR | 2012 | INTERNATIONAL: MOUNTING BRACKET MOUNTED ON WRONG SIDE OF CROSSMEMBER AND THE LOWER SIDE OF MOUNTING BRACKET HAS AIR HORN MOUNTED, ALLOWING POSSIBLE C |
| IK-0500028 | INTERNATIONAL | LONESTAR | 2011 | NAVISTAR: POWER STEERING COMPLAINT ON LONESTAR UNITS WITH CAT ENGINES. CHASSIS BUILT WITH THE CAT ENGINE MAY EXPERIENCE A POWER STEERING PERFORMANCE |
| IK-1201157 | INTERNATIONAL | LONESTAR | 2014 | IK1201157 - UPDATE FOR EXCESSIVE LUBRICATION OIL CONSUMPTION<br /> |
| IK1900198 | INTERNATIONAL | LONESTAR | 2014 | MAXXPOWER NO IDLE BATTERY-POWERED A/C SYSTEM DIAGNOSTIC GUIDE; MODELS EQUIPPED WITH FEATURE 16UZL<br /> |
| AFC-11910 | INTERNATIONAL | LONESTAR | 2009 | NAVISTAR: SOFTWARE UPDATE INFORMATION FOR THE A/C AND BLOWER MOTOR. *RM<br /> |
| IK1100031A | INTERNATIONAL | LONESTAR | 2017 | HARD TO CRANK CONDITION ON VEHICLES WITH HYDRAULIC CLUTCH LINKAGE AND SOLO CLUTCH<br /> |
| TB-IK-0800172 | INTERNATIONAL | LONESTAR | 2008 | INTERNATIONAL TRUCK: WRITTEN PROCEDURE IS TO SIMPLIFY AND CLARIFY THE OPERATION OF IMPROVING CAB CIRCUIT GROUNDS. SYMPTOMS ARE: CLUSTER LOCKUP; TRAIL |
| IK0900087 | INTERNATIONAL | LONESTAR | 2014 | TEMPERATURE RADIATOR DIAGNOSTICS<br /> |
| IK1900225 | INTERNATIONAL | LONESTAR | 2015 | AIR CONDITIONING MECHANICAL PRESSURES DIAGNOSTICS<br /> |
| G-10918 | INTERNATIONAL | LONESTAR | 2010 | NAVISTAR SERVICE BULLETIN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ON CERTAIN PROSTAR AND LONESTAR MODEL TRUCKS THERE IS A FIELD CAMPAIGN TO INSP |
| IK1900207 | INTERNATIONAL | LONESTAR | 2014 | HVAC DIAGNOSTIC INFORMATION<br /> |
| IK-1900144 | INTERNATIONAL | LONESTAR | 2008 | HVAC SYSTEM COMPRESSOR AND DISCHARGE HOSE FAILURE DIAGNOSTICS AND REPAIR PROCEDURES. NAVISTAR. *KB<br /> |
| IK-0800180 | INTERNATIONAL | LONESTAR | 2010 | INTERNATIONAL TRUCK: STARTER, ALTERNATOR AND ENGINE BLOCK GROUNDING. TO SIMPLIFY AND CLARIFY THE OPERATION OF IMPROVING STARTER FRAME GROUND; ENGINE B |
| IK1100031 | INTERNATIONAL | LONESTAR | 2015 | HARD TO CRANK CONDITION; EQUIPPED WITH HYDRAULIC CLUTCH SYSTEMS<br /> |
| IK1100025 | INTERNATIONAL | LONESTAR | 2015 | CLUTCH SERVICE INFORMATION; EQUIPPED WITH HYDRAULIC CLUTCH SYSTEMS<br /> |
| IK0400057 | INTERNATIONAL | LONESTAR | 2015 | NEWER BRAKE LIGHT OPERATION<br /> |
| IK1100031 | INTERNATIONAL | LONESTAR | 2014 | HARD TO CRANK CONDITION ON VEHICLES WITH HYDRAULIC CLUTCH LINKAGE AND SOLO CLUTCH<br /> |
| AFC-12943 | INTERNATIONAL | LONESTAR | 2013 | NAVISTAR: SOME VEHICLES MAY EXPERIENCE INCORRECT SEALING ON THE AIR CLEANER INTAKE PIPES. THE AIR INDUCTION SYSTEM MAY NEED TO BE REPLACED. MODELS INC |
| IK1900228 | INTERNATIONAL | LONESTAR | 2014 | VEHICLE AIR CONDITIONING DIAGNOSTICS<br /> |
| IK1900226 | INTERNATIONAL | LONESTAR | 2014 | AIR CONDITIONG CONTROL HEAD DIAGNOSTICS<br /> |
| IK1900225 | INTERNATIONAL | LONESTAR | 2014 | AIR CONDITIONING MECHANICAL PRESSURES DIAGNOSTICS<br /> |
| IK1900223 | INTERNATIONAL | LONESTAR | 2014 | AIR CONDITIONING ELECTRICAL DIAGNOSTICS<br /> |
Subscribe for our latest newslatters
Know if there is a safety problem with your vehicles, tires or car seat, and how to get it fixed.